Engine Overheats

Share on LinkedIn
Share on StumbleUpon
Bookmark this on Digg

Reader Question

Hi Austin, I have a 2003 Ford Taurus and after running the engine for about 30 to 40 minutes coolant comes back up through the overflow bottle.

I am thinking possible small head gasket leak. I did a combustion leak test and no discoloration of the test fluid was seen.

Do you think K&W Block Seal will solve this problem?

Bill

Hello Bill

Well, first thing I would do is get a cooling system pressure test that would tell me if there was an internal (headgasket) or external leak (hoses, water pump etc). If you do not find any leaks I would check for a restriction in the radiator next.

The radiator is prone to junk/rust/calcium build up at the bottom of the radiator which you can not see or flush out with a water hose.  If the coolant can not circulate throughout the system it will boil back up into the overflow bottle like you are experiencing.

I would check the temperature on both upper and lower radiator hoses when the engine is hot and make sure they are about the same temperature…they should be.

If the one hose is much cooler than the other you have a restriction, and the radiator is usually the main culprit.

Using K&W Block Sealer

If you really do still suspect you have a headgasket leaking then YES, K&W engine block sealer is the best thing on the market. You do not need to remove the thermostat, or the spark plugs….if you want to do it my tried and true method.

Just add the sealer to the radiator and top off with tap water then drive 500 miles total.  Drain out the mix and add back the 50/50 water coolant to refill the system. The faster you put on 500 miles the better.  Cross your fingers, and it if works it should be a permanent repair.

Warning, you do not have freeze protection during the 500 miles, so make sure to keep your engine from freezing.

Here is a video I made about overheating issues that might help you.

Click here to submit your review.


Submit your review
* Required Field

Posted in: Over Heating

About the Author:

Austin Davis, consumer car repair advocate. "Hi there! I love to help people solve their car repair problems and I hope my site was helpful to you today. Thank you for stopping by."

Post a Comment